Skip to main page content
U.S. flag

An official website of the United States government

Dot gov

The .gov means it’s official.
Federal government websites often end in .gov or .mil. Before sharing sensitive information, make sure you’re on a federal government site.

Https

The site is secure.
The https:// ensures that you are connecting to the official website and that any information you provide is encrypted and transmitted securely.

Access keys NCBI Homepage MyNCBI Homepage Main Content Main Navigation
. 2020 Mar 20;20(6):1742.
doi: 10.3390/s20061742.

Development of a Flex and Stretchy Conductive Cotton Fabric Via Flat Screen Printing of PEDOT:PSS/PDMS Conductive Polymer Composite

Granch Berhe Tseghai  1   2   3 , Benny Malengier  1 , Kinde Anlay Fante  3 , Abreha Bayrau Nigusse  1   2 , Lieva Van Langenhove  1
Affiliations

Development of a Flex and Stretchy Conductive Cotton Fabric Via Flat Screen Printing of PEDOT:PSS/PDMS Conductive Polymer Composite

Granch Berhe Tseghai et al. Sensors (Basel). .

Abstract

In this work, we have successfully produced a conductive and stretchable knitted cotton fabric by screen printing of poly(3,4-ethylenedioxythiophene) polystyrene sulfonate (PEDOT:PSS) and poly(dimethylsiloxane-b-ethylene oxide)(PDMS-b-PEO) conductive polymer composite. It was observed that the mechanical and electrical properties highly depend on the proportion of the polymers, which opens a new window to produce PEDOT:PSS-based conductive fabric with distinctive properties for different application areas. The bending length analysis proved that the flexural rigidity was lower with higher PDMS-b-PEO to PEDOT:PSS ratio while tensile strength was increased. The SEM test showed that the smoothness of the fabric was better when PDMS-b-PEO is added compared to PEDOT:PSS alone. Fabrics with electrical resistance from 24.8 to 90.8 kΩ/sq have been obtained by varying the PDMS-b-PEO to PEDOT:PSS ratio. Moreover, the resistance increased with extension and washing. However, the change in surface resistance drops linearly at higher PDMS-b-PEO to PEDOT:PSS ratio. The conductive fabrics were used to construct textile-based strain, moisture and biopotential sensors depending upon their respective surface resistance.

Keywords: PEDOT:PSS; conductive polymer composite; flexible electronics; wearable application.

PubMed Disclaimer

Conflict of interest statement

The authors declare no conflict of interest.

Figures

Figure 1
Figure 1
Chemical structure: (a) polystyrene sulfonate (PEDOT:PSS); (b) poly(dimethylsiloxane-b-ethylene oxide) (PDMS-b-PEO).
Figure 2
Figure 2
Effect of WR treatment on knitted cotton fabric: (a) PEDOT:PSS polymer dispersion on untreated fabric (S0); (b) drops of water on untreated fabric (S0); (c) drops of water on water repellent (WR)-treated fabric (S1); (d) PEDOT:PSS polymer dispersion on water repellent (WR)-treated fabric.
Figure 3
Figure 3
Screen printing of conductive polymer composite on knitted cotton fabric.
Figure 4
Figure 4
(a) Schematic design of the conductive textile fabric; (b) actual conductive textile fabric.
Figure 5
Figure 5
Two-point method resistance measurements set-up.
Figure 6
Figure 6
(a) Arduino Nano electronic circuitry design; (b) resistance measurements set-up.
Figure 7
Figure 7
Effect of PEDOT:PSS/PDMS-bb-PEO on thickness.
Figure 8
Figure 8
Load-elongation curve.
Figure 9
Figure 9
SEM: (a) WR treated; (b) PEDOT:PSS coated; (c) PEDOT:PSS-PDMS:PEO coated.
Figure 10
Figure 10
Effect of PDMS-b-PEO concentration on resistance: (a) effect of PEDOT:PSS to PDMS-b-PEO ratio on resistance at different surface area, width kept constant; (b) effect of PDMS-b-PEO on surface resistance.
Figure 11
Figure 11
PEDOT:PSS/PDMS-b-PEO coated cotton electrodes for: (a) strain dynamic response at 0.67 cm/s rate of stretching for six seconds; (b) moisture dynamic response at1 ml/s rate of water spray for six seconds; (c) electrocardiography (ECG) signal using PC-80B; (d) electroencephalography (EEG) signal using OpenBCI board.
Figure 11
Figure 11
PEDOT:PSS/PDMS-b-PEO coated cotton electrodes for: (a) strain dynamic response at 0.67 cm/s rate of stretching for six seconds; (b) moisture dynamic response at1 ml/s rate of water spray for six seconds; (c) electrocardiography (ECG) signal using PC-80B; (d) electroencephalography (EEG) signal using OpenBCI board.
Figure 12
Figure 12
Effect of stretching on surface resistance and sensing stability: (a) Change in resistance due to stretching; (b) surface resistance at different stretching cycles.
Figure 13
Figure 13
Effect of washing on the surface resistance at different PDMS-b-PEO to PEDOT:PSS ratios: (a) surface resistance before and after washing; (b) percentage change in surface resistance due to washing.
See this image and copyright information in PMC

References

    1. Borges B.G.A., Holakoei S., das Neves M.F., de Menezes L.C., de Matos C.F., Zarbin A.J., Roman L.S., Rocco M.L.M. Molecular orientation and femtosecond charge transfer dynamics in transparent and conductive electrodes based on graphene oxide and PEDOT:PSS composites. Phys. Chem. Chem. Phys. 2019;21:736–743. doi: 10.1039/C8CP05382K. - DOI - PubMed
    1. Güney H.Y., Avdan Z., Yetkin H. Optimization of annealing temperature and the annealing effect on life time and stability of P3HT:PCBM-based organic solar cells. Mater. Res. Express. 2019;6:045103. doi: 10.1088/2053-1591/aafdee. - DOI
    1. Hebbar V., Bhajantri R.F., Ravikumar H.B., Ningaraju S. Role of free volumes in conducting properties of GO and rGO filled PVA PEDOT:PSS composite free standing films: A positron annihilation lifetime study. J. Phys. Chem. Solids. 2018;126:242–256. doi: 10.1016/j.jpcs.2018.11.014. - DOI
    1. Ding Y., Xu W., Wang W., Fong H., Zhu Z. Scalable and Facile Preparation of Highly Stretchable Electrospun PEDOT:PSS@PU Fibrous Nonwovens toward Wearable Conductive Textile Applications. ACS Appl. Mater. Interfaces. 2017;9:30014–30023. doi: 10.1021/acsami.7b06726. - DOI - PubMed
    1. Sedighi A., Montazer M., Mazinani S. Fabrication of electrically conductive superparamagnetic fabric with microwave attenuation, antibacterial properties and UV protection using PEDOT/magnetite nanoparticles. Mater. Des. 2018;160:34–47. doi: 10.1016/j.matdes.2018.08.046. - DOI

LinkOut - more resources